Category
Practical guides and technical insights from Relyir Grass, an artificial grass manufacturer in China since 2006.
Two rolls of artificial grass can look identical on a pallet and age nothing alike. Three summers in, one holds its colour and stands back up after a full weekend of use, while the other shines, flattens and fades. The difference was decided long before either roll was cut, at the stage where the yarn ...
Read Article
Why should artificial turf courts be filled with quartz sand? Because the carpet is only half of a playing system; the layer between the blades is the other half. Leave it out and the pile lies flat, the surface drifts, and the carpet looks tired within its first seasons. We tuft, coat and roll carpet ...
Read Article
Order half the sand a lawn needs and the blades start lying down within a season. Order twice as much and the surface turns hard, water pools after rain, and the seams carry weight they were never meant to take. Both jobs tend to come back with the same phone call about a lawn that ...
Read Article
A playground lawn that flattens within two seasons costs a second purchase, a second closure and a second round of complaints. That is why buyers ask how long non-infill grass lasts before they compare prices. The honest answer is a range, not a single number, and the range moves with how the surface is used. ...
Read Article
Two deliveries of the same turf can read as two different lawns once they are seamed side by side. The tone shifts slightly, the seam line shows, and the whole finish looks patchy in daylight. Will my artificial turf match if I order in two batches? Usually not perfectly, and the reasons sit in the ...
Read Article
A contractor opens a non-infill bid with one question that decides the rest: what goes on the acceptance sheet. We build artificial grass rolls on our own line, so the numbers below are the ones our inspectors actually measure. The choice between infill vs non-infill turf is only useful once those numbers are written down ...
Read Article
Two quotes for what looks like the same artificial grass project can sit far apart, and neither number explains the gap on its own. Buyers comparing quotes across artificial turf installations run into the same wall: the rolls look alike in a photo, yet one price lands well below the other. Why does artificial grass ...
Read Article
Sand used to do a quiet structural job on every synthetic pitch, its weight pressing between the blades and holding them vertical. Remove that ballast and one question decides whether the product survives: how does non-infill turf stay upright on its own? We run the full line ourselves, from extrusion through tufting to coating, so ...
Read Article
Most buyers spend weeks comparing turf products and minutes reading the ground the turf will sit on. That order is backwards. When a synthetic lawn disappoints, the fault usually sits below the surface: water with nowhere to go, a base that settles, or a shaded corner that never dries. We build artificial grass rolls on ...
Read Article
